Tesla to recall 53,000 cars over parking brake issue
Tesla says it will recall 53,000 Model S and Model X vehicles to replace faulty electronic parking brakes that may not release properly.
Vehicles assembled between February and October last year contain a small gear that could have been manufactured improperly by Tesla's supplier, according to a statement on the electric-car maker's website.
If that gear were to break, the parking brake could become stuck in place, the company said.
"While less than 5 percent of the vehicles being recalled may be affected by this issue, we are recalling 53,000 vehicles total out of an abundance of caution," Tesla said. "Because of the design of the gear, it is difficult to tell exactly which vehicles are affected.
Tesla reversed gains and fell by as much as 1.7 percent. The shares were down 0.9 percent to $302.69 ($NZ427) in New York trading.
The automaker led by Chief Executive Officer Elon Musk is under closer scrutiny with regards to quality as its market capitalisation has surged to rival the likes of much bigger companies including General Motors and Ford.
Tesla's valuation has been climbing in part due to the upcoming introduction of its most affordable car, the Model 3, which will require manufacturing at much greater scale.
Tesla said it hasn't seen "a single accident or injury" relating to the brake issue, and there have been no reports of the system failing to hold a parked vehicle or stop a vehicle in an emergency.
Only a "very small percentage" of gears were manufactured improperly, the company said.
In November 2015, Tesla recalled 90,000 Model S cars because of a single report of a seat belt not being properly connected.
Today's figure 53,000 vehicles is the automaker's second-largest recall to date.
Tesla produced almost 84,000 vehicles in 2016 and plans to make half a million in 2018, then 1 million in 2020.