Report finds safety testing flaws before tuk-tuk crash that injured six people in Wellington

The report into a tuk-tuk crash in Wellington in December, which injured six people, shows the canopy collapsed on ...
SUPPLIED

The report into a tuk-tuk crash in Wellington in December, which injured six people, shows the canopy collapsed on impact, endangering passengers.

A report into a tuk-tuk crash in Wellington late last year has revealed safety testing flaws put passengers at risk, and probably led to the injuries suffered by six people on board.

The $30,000 investigation into the crash, on Wellington's steep and winding Roseneath Tce in December, was commissioned by the New Zealand Transport Agency after its inspection of the tuk-tuk following the incident raised concerns about its stability and "rollover" strength.

According to the report, obtained under the Official Information Act, five passengers suffered head and facial injuries in the accident, including concussion, cuts and bruises, which required emergency medical care or hospital treatment.

The front right side of the tuk-tuk was significantly damaged.
SUPPLIED

The front right side of the tuk-tuk was significantly damaged.

The report says the vehicle's metal canopy offered "little to no resistance" to the crash, and its supporting pillars also failed to withstand the impact.

READ MORE:
Tuk-tuk licences revoked after Wellington crash investigation
Tuk-tuk tours on hold after crash injures six
Tuk-tuk rolls in Roseneath hills

Tuk-tuks were certified as passenger service vehicles in September, and operated in Wellington and Auckland until they were taken off the roads in February.

The toppled tuk-tuk at the crash scene, in Roseneath Tce, Wellington.
SUPPLIED

The toppled tuk-tuk at the crash scene, in Roseneath Tce, Wellington.

The report, signed off in January, shows the vehicles were incorrectly given safety certificates and, had the issues been addressed, "the level of injuries would likely have been reduced".

"The condition of the vehicle does not meet the expected behaviour of a rollover frame; the vehicle structure has failed to provide reasonable protection to occupants."

WHY WERE TUK-TUKS INCORRECTLY CERTIFIED?

The canopy was not able to withstand the impact of the crash, instead buckling and collapsing.
SUPPLIED

The canopy was not able to withstand the impact of the crash, instead buckling and collapsing.

NZTA hired Palmerston North-based company Sandbox Consulting to investigate the tuk-tuk's performance in the crash and, subsequently, to recommend design changes to improve the vehicles' stability.

Ad Feedback

According to the report, the error occurred because shortcuts were taken during safety testing that deemed the tuk-tuks to be roadworthy.

NZTA rules require a passenger service vehicle to be able to withstand an impact, at its highest corner, of half its maximum weight from side-on and total unladen weight from above, without sustaining permanent damage.

Police officers tend to injured occupants of the tuk-tuk. Skid marks can also be seen on the road.
SUPPLIED

Police officers tend to injured occupants of the tuk-tuk. Skid marks can also be seen on the road.

The independent engineer who issued the safety certificates for the vehicles operated in Wellington by Tuk Tuk Cartel erred by assuming the three-wheeled tuk-tuks would absorb the impact in the same way as heavy vehicles, such as buses, the report says.

The incorrect method was used for "expediency", when a separate analysis should have been carried out.

Unlike a heavy vehicle, the tuk-tuks would be unlikely to evenly distribute the force of any impact, making the front more vulnerable should it hit the ground and potentially "leading to failure".

The report also finds the steel canopy did not qualify as a rigid structure, as is assumed of heavy vehicles.

The police serious crash unit investigated the accident and deemed neither the driver nor Tuk Tuk Cartel was at fault.

Glen Varcoe, who set up Tuk Tuk Cartel with his brother Jeremy Marr, said the report appeared "interesting", and he would take a couple of days to consider it before commenting further.

NZTA said on Monday that the independent engineer involved was currently being investigated by the Institution of Professional Engineers.

He was issuing safety certificates as "a suitable qualified person", an NZTA spokeswoman said, but was not an NZTA appointee.

"Because there is an ongoing investigation, the Transport Agency is not able to comment on the circumstances that resulted in the vehicles being deemed compliant with PSV requirements.

"All Transport Agency-appointed independent vehicle certifiers are subject to performance monitoring and auditing by the agency with respect to certifications carried out under those appointments."

She added: "The process used for certifying the vehicles as passenger service vehicles was the correct one, but the crash investigation by the NZTA has indicated that the vehicles did not comply with the relevant technical requirements of the passenger service vehicle rule."

WHAT NOW?

New testing criteria has been introduced to assess the stability of three-wheeled vehicles before they are issued with a certificate of fitness.

The testing will ensure "real-world stability" similar to that of a four-wheeled vehicle, and includes a raft of engineering calculations. 

It was unclear whether the necessary improvements could be made to tuk-tuks to bring them to an acceptable safety level, the report said.

NZTA said it was up to tuk-tuk operators to decide if they wanted to reapply for an operating licence if and when they were deemed roadworthy.

 - Stuff

Ad Feedback
special offers
Auckland

Cliff collapse swallows back yard video

All that was left was a slab of decking hanging precariously over the cliff edge.

Deck hangs precariously after 10-metre cliff collapses on a coastal property in east Auckland.

Errors undo Auckland

The Counties Manukau defence wrap up Auckland wing Caleb Clarke in their 16-14 win in Pukekohe.

Derby defeat for Auckland and Canterbury get set to bring All Black back to NPC arena.

Power pole crashes cut power

FILE PHOTO: Lines company Vector was called to restore power to Whitford and Mt Albert after cars crashed into power lines.

Two cars have hit power poles in Auckland, causing outages in Whitford and Mt Albert.

Double rainbow in Coromandel

Rachael Scott snapped these pictures of a vivid double rainbow over the Coromandel Peninsula.

A spectacular double rainbow had one motorist looking for the pot of gold.

Wellington

Stream win WelTec Premiership

St Patrick's College, Silverstream celebrate their win over Wellington College in the WelTec Premiership final on Sunday.

A 17-11 win over Wellington College saw St Pat's Silverstream win their first Wellington premier rugby title since 2012.

Plastic seawall no-go video

The Paekakariki sea wall, looking north.

Kapiti bureaucrats ditch plan to build $10.9m plastic seawall after reports reveals it would bulge.

One dead in two-car crash

Emergency services are attending a serious crash on the Napier-Taupo Highway.

State Highway 5 between Napier and Taupo reopens after fatal crash that also left four injured.

Falling rocks ahead video

Falling rock on August 18 in the Ngaio Gorge in Wellington.

Tiny blue car just escapes falling boulders as dashcam captures danger in the Ngaio Gorge.

Canterbury

Anger over flooding and erosion

Alastair Burgess, commodore at the South New Brighton yacht club, surveys erosion near where the proposed new club will ...

Every time rain is forecast, Sam Hawkins clears sand and stones from the stormwater outlet behind his holiday park.

Four-lane highway?

Christchurch's motorway project is already part of the Government's Roads of National Significance scheme.

Christchurch to Ashburton route earmarked for upgrade in $10.5b roading investment.

$250k for hospital beds, helipad

Ruby Allen suffered from an acute respiratory illness from seven months to age five.

In a night, generous Cantabrians raised $156k to help the cash-strapped health system.

Idea to keep Cathedral a ruin

A Walker Community Architects' plan for Christ Church Cathedral.

Architects suggest keeping Christ Church Cathedral as a ruin surrounded by reflective pool.

Waikato

The great Pinetree falls gallery video

All Blacks legend Colin Meads.

OBITUARY: All Blacks legend leaves one of the great rugby legacies.

Sir Colin Meads dies video

Sir Colin Meads has died, aged 81.

All Blacks legend Sir Colin Meads has died following a year-long battle with cancer.

Pulled from river after crash

Rescuers work to free the couple from the ute shortly after it plunged 10 metres down the bank into the Waikato River at ...

Bystanders in Cambridge, including an off-duty police officer, saved two from submerged car.

Marae teems with politicians

Mana Party leader Hone Harawira spoke to the crowd.

It was mainly a Maori Party party, though, with a sprinkling of National MPs.

Taranaki

Early changes almost prove costly

19082017 News Photo ANDY JACKSON/STUFF.  Mitre 10 cup rugby, Taranaki V Waikato at Yarrow Stadium in New Plymouth.  Seta ...

Plenty to work on for Taranaki ahead of next match.

McLeod ready to bolt

New Plymouth District Councillor John McLeod has decided he will retire from the council at the end of this term.

New Plymouth District councillor John 'Horse' McLeod says he will step down in 2019.

A promise to fight for Tangaroa

The protesters held hands and made a promise to Tangaroa to protect it for future generations.

Hundreds protesting the recent seabed mining decision say the fight has just begun.

Birthday business gift

Anika has been learning the value of money.

They've gone one better than the good ol' roadside lemonade stand.

Manawatu

Karen community celebrates

The Karen community hold their first Wrist tying ceremony in Palmerston North. Keelar Pasta, 13, has a go at wrist tying.

Amid music, traditional food and dress, Karen people are celebrating their culture.

$10.5b roading plan

Manawatu Gorge will be a roading focus for the National Government.

Major upgrade to stricken Manawatu Gorge part of ambitious vision to improve New Zealand's roads.

Volunteering in Jordan

Zoe Dekker will head to Jordan to help Syrian refugees. She is walking 100km with her father, Paul Dekker, to raise money.

Zoe Dekker is heading to Jordan to help Syrian refugees.

No injuries after crash

Police attended a one-car crash on Manawatu's Saddle Rd.

Police were called to a one-person car crash on Friday night.

Nelson

Bylaw divides opinion

The bylaw was created to deal with Lewis Stanton and the issue of freedom campers in the city.

The council's bylaw to ban rough sleeping, and require a permit to protest, is put under the legal microscope.

Indoor market planned

Tony Vining and Gill Ireland inside the former Mill building on New St, now destined to house a microbrewery.

A new indoor market could soon set up shop in the Nelson CBD.

Hansen: Squire 'phenomenal'

SYDNEY, AUSTRALIA - AUGUST 19:  Liam Squire of the All Blacks is tackled during The Rugby Championship Bledisloe Cup ...

All Blacks No 6 "lovely to watch" as he stepped up in Sydney, coach Steve Hansen says.

Humans of Nelson

Humans of Nelson

A national storytelling initiative has hit Nelson, driven by a  passionate group of locals.

Marlborough

Push for change on plastic bags

Marlborough District Council solid waste manager Alec McNeil says more than 900 people have taken part in a survey on ...

The results are in, and the people are pushing for a charge on plastic bags.

Eduction issues

Marlborough Girls’ College acting principal Jo Chamberlain.

What are our aspirations for our young people today and in the future, and how best do we as a local community support them?

Wine on tourists' agendas

Tourists enjoy wine and food at Black Barn Vineyards in Hawkes Bay.

Cultured wine tourists spend more, stay longer, and are looking for a social experience.

A different class

New classrooms at Spring Creek School, near Blenheim, offer an improved learning environment.

Removing walls in the classroom is not just about removing physical barriers, but about breaking down obstacles to learning.

South Canterbury

TBHS First XV knock over Christ's

TBHS wing Tevita Eukaliti has too much pace for the defence on his way to scoring in the corner.

Timaru Boys' High School First XV show too much class in victory over Christ's College.

ESOL numbers rise

Waimataitai School ESOL students, from left, Bogdan Stoiljkovic, 8, Lusiana Isaako Tuala, 7, and Pratistha Naicker, 7.

Dairy industry and affordability linked to increase in number of ESOL students.

Offering support for fathers

Jason Brokenshire looks at a recent photo of him with his three children.  He hopes to set up a support group for fellow ...

Timaru man wants to create awareness and support for other fathers after separation.

Hospital services key 

Timaru Hospital.

Services key to Timaru Hospital rebuild, observers and sector groups say.

Southland

South's top cop defends officers

Southern district commander Superintendent Paul Basham says "some things can go wrong sometimes".

Alleged murder, stalking and sexting cases involving police may harm reputation of hard-working officers, top cop says.

Car hits cop, dog

The scene on Dee St, Invercargill, where a police officer and dog were hurt as a spiked car came to a halt.

A policeman and dog went under a car as officers tried to subdue a driver in Invercargill.

Milestones for accountants

Mervyn Gillick , 95,was the oldest member in attendance at the Chartered Accountants Australia and New Zealand Southland ...

There was no shortage of experience on hand at a chartered accountants members lunch.

Dunedin Hospital plans welcomed video

Prime Minister Bill English flanked by ministers, Michael Woodhouse, left, and Dr Jonathan Coleman while in Dunedin on ...

Dunedin civic leaders are backing plans for a new hospital to be built in the central city.

Ad Feedback